An intermittent loss of speed control can happen soon after the transaxle input or output speed sensor has been replaced. The problem is most likely caused by bad connectors.
Resources for the Repair and Maintenance of your 1991 Dodge Caravan
1991 Dodge Caravan
1991 Dodge Caravan Problems
Triggered by a short in the rear wiper motor/circuit (which causes a fuse to blow), the airbag warning light can illuminate erroneously.
A refrigerant leak at the rear AC expansion valve and/or AC evaporator seals may cause the rear AC not to work.
A problem with the sliding door track and door stops can allow the door to slide out of the track and fall off the vehicle. This is more common when doors are opened fast and allowed to hit the stops with a lot of force.
Windows may not roll up or down, resulting in a "ratcheting" noise. This is often caused by the plastic ribbon gear (flex tracks) on the regulator that breaks. Flex tracks are easily replaced by removing the door trim panel.
1991 Dodge Caravan Recalls (Recent)
Summary: VEHICLE DESCRIPTION: LIGHT DUTY PASSENGER MINIVANS WITHOUT REMOTE RELEASE. THIS IS NOT A SAFETY RECALL. THERE HAS BEEN NO DETERMINATION THAT A SAFETY DEFECT EXISTS WITH THE MINIVAN LATCHES. CHRYSLER IS CONDUCTING A SERVICE CAMPAIGN TO REPLACE THE LIFTGATE LATCH ASSEMBLY OF THE AFFECTED MINIVANS. IN A COLLISION, THE REAR LIFTGATE LATCH ASSEMBLY COULD OPEN.Learn more »
Summary: VEHICLE DESCRIPTION: MINI VANS. THE BOLTS USED TO ATTACH THE STRUT TO THE BODY AND THE REAR LIFTGATE CAN ACCUMULATE FATIGUE DAMAGE IF THREE FACTORS COMBINE. IF THE BOLT IS LOOSE, THE GAS STRUT IS OVER-PRESSURIZED, AND THE FREQUENCY OF OPENING AND CLOSING CYCLES IS HIGHER THAN FOR THE AVERAGE CUSTOMER, THE BOLT CAN FAIL.Learn more »
Summary: VEHICLE DESCRIPTION: MINIVANS. THE LEFT HAND WINDSHIELD WIPER PIVOT DRIVE ARM WAS NOT MECHANICALLY STAKED TO THE PIVOT SHAFT.Learn more »
Summary: THE ANTI-LOCK BRAKE SYSTEM HIGH PRESSURE PUMP MAY BE POROUS WHICH WILL RESULT IN BRAKE FLUID LEAKAGE.Learn more »
1991 Dodge Caravan Questions and Answers
I WAS DRIVING DOWN THE HIGHWAY AND ENGINE DIED . I HAVE REPLACED THE COIL , THE IGNITION MODULE IN THE DISTRIBUTOR AND THE ENGINE COMPUTER MODULE BUT IT STILL WON'T START .
91 caravan with 3.0 starts hard when cold any time the temp get to around 40 it wont start i have replaced the ADS (auto shutdown relay) and when its cold you can not hear the fuelpump activ...
91 caravan with 3.0 starts hard when cold any time the temp get to around 40 it wont start i have replaced the ADS (auto shutdown relay) and when its cold you can not hear the fuelpump activate. bu...
my tire blew 2 days ago. when we put the spare on the van would not turn over or make any noises. all the power works on everything and we tryed jumping it but it just wont start. there is gas,oil,...
1991 Dodge Caravan Reviews
i need help to put the front seal in 1991 dodge 3.0 caravan cargo.
Have a 1991 Caravan C/V Van has over 350k and still running strong... Trans rebuilt 80k ago
My Caravan has 198,000 miles it has been through floods where it was floating in muck haven't had to replace anything except the starter after the flood. The transmission is now going out and I want to replace it as this van keeps on running it's a real beast and still looks okay.