» » » 2005

Resources for the Repair and Maintenance of your 2005 Chevrolet Silverado SS

2005 Chevrolet Silverado SS

Image for car images Chevrolet 2003 2007 Chevrolet Silverado SS size thumb

2005 Chevrolet Silverado SS Problems

Suspension & Steering -- Verified

The steering may develop a clunk type noise from the upper intermediate steering shaft.  Our technicians tell us that you should check with you local GM dealer to find out what the latest repair is for this condition.

Electrical & Lights -- Verified

The daytime running lights are prone to burning out. Our technicians tell us that the light sockets may show signs of heat damage but usually are OK. Always be sure to use the correct replacement bulb for the best life expectancy. The new bulb recommendation for 2003 models is #4114K (trade number).

Exhaust & Emissions -- Verified

The muffler heat shield may become loose on the muffler causing a rattle or popping noise. Our technicians tell us there is a kit available from GM to correct this problem.

Brakes -- Verified

A poor electrical ground under the battery tray may cause the ABS warning light to illuminate. Our technicians tell us that cleaning and properly securing this ground and also the main ABS ground on the frame rail below the drivers door may be necessary.

Brakes -- Verified

Units with 4 wheel disk brakes may develop at situation where the park brake does not hold as it should. Our technicians tell us this can be caused by worn park brake shoes located inside the drum section of the rear brake disks. The worn shoes should be replaced and properly adjusted to correct this issue.

2005 Chevrolet Silverado SS Recalls (Recent)

Body, Interior & Misc., July 21, 2005

RepairPal Expert Overview:

The second row center seat belt routing may make it difficult to position correctly on smaller passengers. If the seat belt rides up to fit around the abdomen, the risk of internal injury is increased in a crash. Dealers will cut the guide loop, remove a portion of the loop, and the remaining sides should be folded over and secured with a retainer. The recall began July 21, 2005. The GM recall number is 05037.

Learn more »

Brakes, March 23, 2005

RepairPal Expert Overview:

On vehicles equipped with the Bosch hydraulic brake booster, the boost pressure accumulator may crack and break away from the hydro-boost assembly during normal operation. If this were to happen while the hood is open, fragments from the accumulator could injure people standing in the immediate area. The loss of fluid while driving would cause increased steering and braking effort and a crash could occur without warning. Dealers will test the hydro-boost assembly for function of the two-function valve. If the hydro-boost assembly fails the test, it will be replaced free of charge. The recall began March 23, 2005. The GM recall number is 05006.

Learn more »

Drive Train, February 22, 2005

RepairPal Expert Overview:

Under certain conditions, the shift lever position indicator located in the instrument cluster may not illuminate. If the indicator does not illuminate, the driver may not know which gear the vehicle is in. This could result in the vehicle moving in an unintended direction, increasing the risk of a crash. Dealers will reprogram the instrument panel cluster to correct this concern. This recall is expected to begin on February 14, 2005. The General Motors recall number is 05023.

 

Learn more »

Engine, August 31, 2006

RepairPal Expert Overview:

The retainer clip for the fuel rail pulse damper may fracture and allow the damper to come loose from the fuel rail. A fuel leak in the presence of an ignition source may result in a fire. Dealers will replace the engine fuel rail pulse damper free of charge. The recall began August 31, 2006. The GM recall number is 06080.

Learn more »

Suspension & Steering, October 14, 2005

RepairPal Expert Overview:

Some vehicles have a power steering hose that was not made to specification and may rupture under extreme steering conditions. If this were to happen, power steering assist would be lost and steering effort would increase. On vehicles equipped with hydro-boost brakes, braking effort would also increase. If power steering fluid were to spray on hot engine parts, an engine compartment fire could also occur. Dealers will inspect the power steering hose(s) for the two suspect date codes and replace them if needed. The recall began October 14, 2005. The GM recall number is 05086.

Learn more »

2005 Chevrolet Silverado SS Questions and Answers

05 SS, 2005 Chevrolet Silverado SS, Fountain Valley, CA

I have a programmer pluged into the vehicle and it says No communication check key is on.The manufacturer of the programmer gave me a new unit and said to go to the Dealer (chevrolet) and have the ...

Railroad Man, 2005 Chevrolet Silverado SS, Acworth, GA

I have a 2005 Chev Tahoe & SS Silverado and both stereo's get so hot on the front screen, back in 2007-08 the cd players I guess got so hot the cd are melted to the inside or something. H...

Write a Review About Your Car

2005 Chevrolet Silverado SS Reviews

Own a 05 ss after a year had to replace both front wheel bearing out of my own pocket, expense!! Other then that love my truck

I LOVE my 2005 Chevy Silverado SS, black in color, I personally have chosen not to mod it out, and keep it all stock. So far so GOOD.

Recent Repair Estimates