» » » 2002

Resources for the Repair and Maintenance of your 2002 Chevrolet Silverado 2500

2002 Chevrolet Silverado 2500

Image for car images Chevrolet 1999 2002 Chevrolet Silverado size thumb

2002 Chevrolet Silverado 2500 Problems

Heating & Air Conditioning -- Verified

One or more heater & AC (HVAC) air delivery and/or temperature mode door actuator may fail. This can result in incorrect air delivery or temperature. If this occurs, fault code(s) stored in the HVAC control module should be available to assist with diagnoses.

Drive Train -- Verified

The 4WD transfer case encoder motor position sensor or the selector switch may fail causing the service 4WD message to be displayed. Fault code(s) stored in the transfer case control module will be of assistance in determining the exact fault causing the message to be displayed.

Miscellaneous -- Verified

The CD player may fail due to an internal fault with the radio. Our technicians tell us that in most cases, the radio unit will need to be sent to a specialty repair shop to correct this issue.

Electrical & Lights -- Verified

The daytime running lights are prone to burning out. Our technicians tell us that the light sockets may show signs of heat damage but usually are OK. Always be sure to use the correct replacement bulb for the best life expectancy. The new bulb recommendation for 1999-2003 models is #4114K (trade number).

Electrical & Lights -- Verified

It is common for the fuel level sensor in the fuel tank read the fuel level incorrectly. The sensor must be replaced to correct the condition. Our technicians recommend having the complete fuel pump module replaced on high mileage vehicles.

2002 Chevrolet Silverado 2500 Recalls (Recent)

Body, Interior & Misc., September 18, 2004

Summary: ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.

Learn more »

Brakes, July 29, 2005

Summary: ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS AND BUILT WITH EITHER PBR PARKING BRAKE SYSTEMS OR TRW PARKING BRAKE SYSTEMS, THE PARKING BRAKE FRICTION LININGS MAY WEAR TO AN EXTENT WHERE THE PARKING BRAKE CAN BECOME INEFFECTIVE IN IMMOBILIZING A PARKED VEHICLE.

Learn more »

Brakes, September 22, 2005

Summary: CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. THIS CONDITION IS MORE LIKELY TO OCCUR IN ENVIRONMENTALLY CORROSIVE AREAS. THIS RECALL WILL BE LAUNCHED IN THE "SALT BELT" STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MARYLAND, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA ONLY.

Learn more »

Engine, December 3, 2003

Summary: SOME 2WD AND 4WD PICKUP TRUCKS, CONVERTED TO EITHER DEDICATED OR BI-FUEL COMPRESSED NATURAL GAS (CNG) FUEL USAGE, WERE ASSEMBLED WITH A THROTTLE CABLE THAT CAN CONTACT AND RUB THROUGH THE FLEXIBLE PRESSURIZED FUEL LINE CREATING A PINHOLE LEAK OF NATURAL GAS TO THE ATMOSPHERE.

Learn more »

2002 Chevrolet Silverado 2500 Questions and Answers

qq_lisa, 2002 Chevrolet Silverado 2500, Diesel, Valrico, FL

We have replaced both front wheel hub assembly. Stil can not get the light to go off.

bigdaddy895, 2002 Chevrolet Silverado 2500, Creswell, OR

I need to change my injector pump I would like to find instructions

Plaker, 2002 Chevrolet Silverado 2500, Effingham, NH

There are two types and I need the right on.

jaydirtbiker, 2002 Chevrolet Silverado 2500, 6.0L V8, International Falls, MN

The truck started with it not idleing so i changed the fuel filter and it went away. Now it will idle up to 3000 rpms in park or neutral and about 1500 in gear even on the brake or not. I disconnec...

Recent Repair Estimates