2008 Chevrolet Express 1500 Repair and Maintenance

A guide to problems, costs, maintenance and repair for your 2008 Chevrolet Express 1500

Get a Repair Estimate
Guaranteed by certified locations nationwide. Learn more
Get a Repair Estimate For Your 2008 Chevrolet Express 1500
RepairPal estimates are guaranteed at over 1,700 quality certified locations nationwide. Learn more
Repair Estimates

Never overpay. Check prices with our estimator

2008 Chevrolet Express 1500
$
199
to $
603
2008 Chevrolet Express 1500
$
100
to $
366
2008 Chevrolet Express 1500
$
393
to $
1,036
2008 Chevrolet Express 1500
$
103
to $
430
2008 Chevrolet Express 1500
$
420
to $
1,214

2008 Chevrolet Express 1500 Problems

Reduced Power and Check Engine Light

The throttle position sensor (TPS) on the Chevrolet Express 1500 is notorious for failure which causes:

This issue is related to the throttle position sensor, and can be caused by faulty wiring to the TPS, bad connection at the TPS, or a failed TPS.

To correct this issue, the wiring harness, connector, and throttle position sensor must be inspected, tested, and/or replaced. The most common cause is a faulty TPS.

One or More Rear Lights May Not Work

The tail light wiring harness in the cargo area is not protected very well. As a result it may become damaged due to normal wear a tear. This damage can causing some or all of the rear lights to stop working.

Replace spark plugs every 100,000 miles

The spark plugs should be replaced every 100,000 miles. Our technicians recommend replacing the spark plug wires also at this time.

See More Problems (10)

2008 Chevrolet Express 1500 Questions

code 175, runs rough not accelerating, check engine come and off. check engine (1 answer)

on from day one, this problem start all of the sudden.

what is the fuel pressure supposed to be on a 2008 GMC Savana 1500 4.3 motor (1 answer)

when its cold and when it

s hot the difference in the pressure

reset the change oil soon alarm (1 answer)

this code just come up i changed oil cant reset no owners book also low tire alarm checked dont know how to reset code

See More Questions (11)

2008 Chevrolet Express 1500 Recalls

Wheelchair Lift Roll Stop Latch May Become Damaged

Certain vehicles, fitted with a specific Braun wheelchair lift, has a roll stop latch on the outer barrier of the wheelchair lift that may become bent or misaligned over time and with frequent use. Main Mobility is working with Braun to notify owners and Braun dealers will repair the lift as necessary to correct this concern. This recall only pertains to vehicles altered by Main Mobility. General Motors and Ford are NOT involved in this recall.

 

Frame Rail May Be Wider Than Specification, Potentially Causing a Fuel Leak

The frame rail of the vehicle may be wider than intended. If this is the case, the fuel tank may rub on the frame rail and eventually may leak. Leaking fuel presents a fire hazard. Dealers will inspect the vehicle and modify the frame rail if required. The GM recall number is 080205. This recall began on July 30, 2008.

Transfer Case Drive Chain May Fail; Vehicle May Not Be Secure in Park

The transfer case drive chain may fail and cause the AWD system to fail. Chain failure will also prevent the vehicle from being secure in "Park." Dealers will inspect the transfer case and replace it if necessary. The GM recall number is N080244. This recall began on August 15, 2008.

See More Recalls (3)

2008 Chevrolet Express 1500 Reviews

Rated
based on 1 customer reviews
This is a conversion van with 20 inch rubber very rough on bumps

See More Reviews (1)