2007 Audi A3 Quattro Repair and Maintenance

A guide to problems, costs, maintenance and repair for your 2007 Audi A3 Quattro

No_car_image
Get a Repair Estimate
Guaranteed by certified locations nationwide. Learn more
Get a Repair Estimate For Your 2007 Audi A3 Quattro
RepairPal estimates are guaranteed at over 1,700 quality certified locations nationwide. Learn more

2007 Audi A3 Quattro Problems

No Start after Refueling and Popping Noise from Trunk

Popping sounds from the rear of the vehicle may be heard moments after starting the engine, or when slowing to a stop. This noise is from the leak detection pump filling the fuel tank with air, and releasing to retest the system when it finds a fault. The sequence of faults identifying this issue are as follows:

  • Succession of loud pops from rear of vehicle
  • Pops go away, and fuel economy decreases 
  • Check engine light illuminates
  • OBD trouble code P2404 and/or P0441 is stored
  • Engine will not start after refueling (must crank for over 30 seconds)
  • Vibration when slowing to a stop

The cause is a valve which is mounted on the front of the intake manifold, commonly called the N80 valve, or EVAP system purge valve. The valve is designed to open under specific circumstances, but a worn valve will remain open at all times, preventing the pressurization of the fuel tank. 

Correction of the issue is to replace the N80 valve with the latest revision. 

Ignition Coils May Fail

An engine misfire may develop from one or more cylinders resulting in a loss of power and illumination of the Check Engine Light. Our technicians tell us that ignition coil failure is a common cause for this concern. On high mileage vehicles it may be wise to consider replacing all of the ignition coils if one fails to try and avoid future misfire issues on another cylinder.

Lack of power due to throttle system fault

A lack of power may be noted and the Check Engine Light illuminated with various throttle system fault codes stored. Our technicians tell us this is generally caused by electrical connection issues at the throttle body. If this is the case a harness repair kit is available from Audi.

See More Problems (3)

2007 Audi A3 Quattro Recalls

Potential Fuel Leak During Extreme Driving Conditions

Under extreme driving conditions, fuel can leak from the fuel tank vent valve. The internal spring may be too weak to hold the valve closed. Any fuel leak increases the risk of a fire. Dealers will replace the affected valve with an improved design. The recall is expected to begin by November 16, 2009. The Audi recall number is 20Q3/J3.

See More Recalls (1)