In the affected vehicles, there is a flexible steel steel cable that connects the seatbelt buckle to the front seat frame. Over time the cable may fatigue and separate. If the steel cable separates, the seatbelt may not properly restrain the seat occupant, increasing the risk of an injury in a crash. Dealers will inspect and replace the affected seatbelt buckles (lap pretensioners) to correct this concern.
Certain vehicles equipped with 17 inch front brake rotors are being recalled because during vehicle assembly, brake rotors intended for the rear may have been installed on the front. The rear rotors, while the same diameter, are thinner and may result in a front brake pad detaching from the caliper. Braking ability would be reduced suddenly if a brake pad were to detach. The resulting increased stopping distance would increase the risk of a crash. Dealers will inspect the front brake rotors, and install the correct rotors with new brake pads, as necessary to correct this concern.
The fuel gauge may not read accurately, resulting in the possibility of running out of fuel unexpectedly. Dealers will reprogram the engine control module free of charge to resolve the concern.
Increased resistance in the front seat mounted side impact air bag (SIAB) wiring harness can result in the SIAB and seat belt pretensioners not deploying as expected in the event of a crash, increasing the risk of personal injury. Dealers will replace the affected harness connections with soldered connections to correct this concern.
The transmission shift cable adjuster may separate from the cable, causing the shifter to fail and the shift indicator to become inaccurate. Dealers will inspect and replace any affected transmission shift cable adjusters free of charge to resolve the concern.
Fluid may enter the driver's door module, causing corrosion that could result in a short circuit in the door module. A short circuit may cause the power door lock and power window switches to function intermittently or become inoperative. The short may also cause overheating, which could melt components of the door module, producing an odor, smoke, or a fire. Dealers will inspect the driver's door module, if it is functioning correctly, a protective coating will be applied. If the module is not functioning correctly, it will be replaced. The GM recall number is 12180.
eAssist is a hybrid drive system that includes an electric motor to assist the gas engine under certain driving conditions. These vehicles are being recalled because there may be an internal fault with the Generator Control Module (GCM). The module could allow the battery to discharge to the point were the vehicle could stall and/or not start. Also, a burning smell, smoke, and/or a fire could develop in the trunk. Dealers will inspect and replace the GCM to correct this concern.
144 2013 Encores equipped with a heated steering wheel could have a steering wheel retaining fastener that was not properly installed. This could cause the steering wheel to come loose or separate from the steering column, resulting in loss of steering ability. Dealers dealers will inspect the steering wheel and repair as needed.
When driving, if you let your foot off the accelerator, the engine will provide some braking effect unless your transmission is in "Sport" mode. Certain vehicles are being recalled because the transmission may unexpectedly shift into its "Sport" mode, removing the engine braking effect on these vehicles. Unexpected loss of engine braking can increase stopping distance, increasing the risk of a crash. Dealers will update the software in the transmission control module to correct this concern.
The driver's front airbag includes a safety device called a shorting bar - this prevents unexpected deployment of the airbag when it is removed from the vehicle. In this case, the shorting bar may intermittently contact the airbag terminals while it is installed in the vehicle. This could result in illumination of the airbag warning light or the airbag may not deploy when necessary. Failure of the airbag to deploy would increase the risk of injury in the event of a crash. Dealers will replace the steering wheel airbag coil to correct this concern.