2005 BMW 525i Problem Reports

RepairPal Verified 2005 BMW 525i Problem Reports

Report A Problem
View:Most ReportedNewestRepairPal Verified

The front thrust rod bushingsalso referred to as tension strut bushingsare known to fail occasionally. The oil-filled rubber mounts weaken and crack over time, causing a mushy road feel and shuddering in the steering wheel when going over bumps. These worn bushings should be replaced.

The low coolant light may illuminate and/or the engine may overheat as a result of a coolant leak from the water pump. The leaking pump will require replacement and the entire cooling system should be inspected for leaks as it is not uncommon to find multiple leaks on higher mileage vehicles.

Overheating can cause severe engine damage. If the engine begins to overheat it is recommended to stop at the first available location and have your vehicle towed to a repair shop.

The thermostat may fail resulting in engine overheating and/or illumination of the Check Engine Light. Replacement of the thermostat along with a complete inspection of the cooling system will be necessary to correct this concern.

Overheating can cause severe engine damage. If the engine begins to overheat it is recommended to stop at the first available location and have your vehicle towed to a repair shop.

It is not uncommon for the radiator to develop a coolant leak. A leaking radiator will require replacement. When a leaking radiator is replaced the entire cooling system should be inspected and if any additional leaks are found they should be repaired also.

Overheating can cause severe engine damage. If the engine begins to overheat it is recommended to stop at the first available location and have your vehicle towed to a repair shop.

An engine coolant leak may develop from the expansion tank resulting in engine overheating. When a cooling system component fails the entire cooling system should be inspected. It is not uncommon to find additional component have failed or are leaking.

Overheating can cause severe engine damage. If the engine begins to overheat it is recommended to stop at the first available location and have your vehicle towed to a repair shop.

A creak or squeak can be heard from the top of the front or rear doors. This noise is most noticeable when the windows are fully up. The noise is caused by the decay of the flocking material on the door seals. New door seals, Teflon tape, special lube, or a combination of all of these may be needed to eliminate the noise.

Valve cover gasket leaks are common after 60,000 miles. Symptoms will include oil drips under the vehicle and burning oil smell from the engine compartment.

A fluid leak may develop from one or more power steering hose. When a leak is being repaired, it is not uncommon for multiple hoses to be replaced.

If the brakes are squealing, there's a good chance it is the brake pad wear sensor. A new design was implemented in January 2006 and can be identified by its green color.